Anyone have this problem? The rear shoulder harness belts are damp whenever it rains hard. Must be a leak somewhere. I have the factory roof rack...

 

By the way, I have the factory roof rack and sunroof.

 

I havn't noticed this in my HHR yet. I did have a Pontiac Montana with the roof rack that had this problem the carpet of the driver side just behind the sliding door would get wet too. Same thing there, only after a really hard rain. The leak was never found in the van. Hope you can get yours straightened out. Best of luck!

 

check the drains on the sunroof tracks, maybe get a can of that computer compressed air, and try to blow them out

 

I seldom have passengers in the back seat but I'll try to remember to check them the next time it rains. I, too, have a roof rack.

 

Sorry to bump this old thread but just noticed the same thing on my 06 hhr... Roof rack (stock) and sunroof options... did anyone figure this one out yet?

 

Bumping to see if anyone has any more ideas?! Thanks in advance.

 

Check out my reply on:
https://www.chevyhhr.net/forums/problems-service-repairs-42/rear-shoulder-belts-wet-30084/

Hope it helps you get to the bottom of it.

 

Cool Thanks! I know the area around the molding that you are talking about and the pin, but didn't dawn on me to put some silicone on it! :)..

 

Since I also squeezed some silicon in the gap between the roof panel and the quarter panel (where they join up), you might want to check that out too. I can't be sure which spot "worked". Good luck.